Your usage of AdBlue depends on your vehicle use, load being carried and driving style. As a guide, a tank of AdBlue typically lasts 12,000 to 16,000 km of normal driving for Everest, and 9,000 to 11,000 km for Transit & Transit Custom.Further information can Remove the two torx screws. Next remove the torx screws from under the back of the bumper. Then pry the cover off starting from each wheel well. It takes a little elbow grease, but all that's left holding the cover on are plastic clips. Here's the Adblue tank with the cover off. There are 3 bolts holding the tank on. When adding AdBlue ®, use a bottle with an anti-spill nozzle. If a bottle without an anti-spill nozzle or a commercial dispenser at a petrol station is used, it could cause leakage or the AdBlue ® fluid to spray out. Do not overfill the AdBlue ® fluid. If AdBlue ® is added unnecessarily, it could cause a problem with the urea tank or damage AdBlue®, a water/urea based operating fluid, is stored in a tank (like diesel fuel), however, unlike fuel it is not injected into the engine, but directly into a specially modified part of the vehicle’s exhaust. This begins a chemical reaction which removes the polluting oxides of nitrogen (NOx), converting them into harmless water and It turns out that urea, which is being sold under the more marketable name “Diesel Exhaust Fluid” for about $2.50 a gallon, is also a chemically efficient way to reduce nitrogen oxide emissions produced by diesel engines. DEF (32.5 percent industrial urea and 67.5 percent deionized water) is held in a separate storage tank and injected as a At a very rough estimate I seem to be getting about 6000 miles to 10 Litres of Adblue My Focus estate 2.0L holds over 10 litres of Adblue. Only filled twice in 12K miles. Both times I refilled it when I had about 500 miles left. Managed to pour a full 10Lts in without any problem. Fuel tank capacity : 50 l 13.21 US gal | 11 UK gal: AdBlue tank : 15 l 3.96 US gal | 3.3 UK gal: Max. roof load : 100 kg 220.46 lbs. Permitted trailer load with brakes (12%) 1500 kg 3306.93 lbs. Permitted trailer load without brakes : 750 kg 1653.47 lbs. Permitted towbar download : 75 kg 165.35 lbs. Dimensions; Length It looks as if the level sensor in the AdBlue tank did not recognise the fill-up. The problem is quite common with the AdBlue systems of all vehicle manufacturers. You yourself have done everything that can be done. A garage must try to reinitialise the AdBlue system using a diagnostic tester. This will force the level sensor to reset the level. 7zw8J7P.